印刷车间印染厂废气收集处理设备

印刷车间印染厂废气收集处理设备

印刷等车间经常会产生臭味，且这些臭味中含有危害人身体的**废气尾气，这些尾气不能等到处理会大大影响员工身体健康和生产车间工作效率，因此对车间内的废气应当做适当的收集处理，达到环保要求，即不影响企业形象同时也不影响周边的环境。

VOC沸石转轮浓缩GRTO装置

安居乐VOC沸石转轮浓缩GRTO装置简介:

Zeolite Rotary Concentrator Wheel+ GRTO:

对于低浓度?大风量的VOC污染废气，上海安居乐环保科技股份有限公司推出自主知识产权的GRTO工艺，进一步完善了传统的VOC浓缩+RTO蓄热燃烧装置工艺，可以将低浓度、大风量的污染空气浓缩为小风量、高浓度的废气后进行热力燃烧处理，效率提升，安全提升，而且可以降低运行成本，实现低成本、高效率VOC尾气处理达标排放，是行业良好的**挥发性VOC和恶臭HAP废气环保治理工艺。

How to treat low concentration with large air flow waste stream?  Shanghai Anjule has patent designed solutions with the zeolite concentrators to reduce the air flow of the pollutant and concentrate the VOCs before the RTO treatment. Improve the removal efficiency, reduce the operating cost while meeting the regulations.  This is a leading technologies in treating VOCs and HAP.

常规**废气浓缩转轮和RTO（RCO）处理流程如下：

The process flow for zeolite rotary concentrator wheel+ RTO (RCO)

安居乐的工艺技术更加贴近废气工况，以大风量的喷漆废气处理为例：
车间排放**废气通过总管道送至G涡流净化塔做漆雾颗粒去除处理，后经过除雾器，再经过专门设计的组合过滤器后，由VOC沸石浓缩转轮吸附区吸附，吸附效率为90%以上；排放废气由吸附风机抽出，并达标排放；
浓缩转轮吸附住的**物，从转轮脱附区域脱附出来进入RTO高温氧化处理

Anjule technology can be applied to work with the process specifications.  For example, emission from coating industrial has the characteristic of high air volume: the waste gas was sent to the G-vortex column to remove particulate.  After the dehumidifier process, the waste gas was sent to a specially designed filter before entering the rotary concentrator for VOCs adsorption. The removal efficiency can achieve VOC removal efficiency above 90%.  A system fan was installed to release the cleaned air, which is in compliance with the regulations. The air stream then transfer to the RTO for further treatment.

   一、转轮入口G涡流净化塔
安居乐G涡流洗涤净化塔采用*特的涡流结构；净化去除**废气中漆物，以满足转轮入口条件；优点：1、不易堵塞，*更换填料。2、运行成本低。3、漆粒去除效率高，防治漆粒积蓄在转轮上发生火灾。

1. Rotary entrance with G-vortex column

Anjule G-vortex column has a unique vortex structure, purify and remove the paint organic substance from gas.

The advantage:  1. Avoid the blockage of the packing media; reduce the operating cost; and achieve high removal efficiency of VOC substance. Minimize the accumulation of the paint substance on the rotary and at a result prevent fire hazard.

   二、先进转轮装置

2. Advance rotary device

    安居乐设有专门的VOC处理实验室，废气治理实验工程中心，转轮装置引进日本，实验测试具体成分的转轮效率，**项目的成功率。转轮吸附装置的优点体积小、操作方便、压降低；它可以连续地将大的废气流量处理成浓度足够低的净化气，而解吸出来的气体则浓度高而流量低，从而进入低风量RTO装置彻底燃烧。

Aujule has set up a laboratory and an engineering center for the design of the exhaust gas VOC treatment.  The rotary wheels are imported from Japan; the VOC compounds removal rate are measured in a laboratory to ensure the successful treatment for the environmental projects.

The advantage of our rotary concentrator:  small size, convenience, low pressure lost and work continuously to concentrate low VOC concentration waste gas. The rotary processed gas has a high concentration of VOC with less volume and therefore reduce the amount of the waste gas for the RTO treatment.

   三、安全性高
安居乐少见**设计的GRTO工艺充分考虑了消防、防爆等安全因素，运行稳定，安全可靠，工艺完整。

3. Safety guarantee

Patent designed of Anjule GRTO has put the fire, explosions and other safety factors into fully consideration.  The operation of the GRTO is steady, safe and reliable.

  四、技术先进性
  GRTO 控制系统设有软硬体联锁，可通过温度、压力等反馈，及时调节响应联动器件，可有效**系统安全。RTO控制系统采用PLC,安置在控制盘体内；配有火焰强度显示、高温控制器、报警、复位、开关机、紧急停机以及记录仪；RTO系统与产线进行无缝衔接，确保不影响现有工艺及生产。

4. Advance Technology

GRTO control system equipped with software and hardware interlocks, through temperature, pressure responses, the system reacts immediately to the safety control of the system. Effectively，protect the safety of the system . RTO control system uses PLC, installed inside of the control panels; equipped with flame intensity detector, temperature controllers, alarm, reset, on and off switch, emergency stop, and a recorder; RTO system works seamlessly with the production line without interfering to the existing production.

  五、运行费用优势
 浓度越高运行成本越低。所以采取合理的技术手段增加**废气进入RTO（RCO）时的浓度，以及减少废气处理量是减少RTO（RCO）投资与提高运行效率的有效途径。

5.  The low operating cost advantage

Lower operating cost can be achieved with high VOC concentration in the waste stream. Using a rotary concentrator to reduce the volume of the waste gas is a feasible way in decreasing the cost.

印刷车间印染厂废气收集处理设备

详情致电：138-1758-0613